摘要
煤基SOFC/IGCC聯合循環發電系統是把先進的燃料電池技術與整體式煤氣化聯合循環技術相結合而成的先進能源動力系統，現在已進入商業化示范運營階段。它是目前實現燃煤發電高效近零排放最先進的發電系統之一，受到了世界各國的普遍關注。
本文對煤基SOFC/IGCC聯合循環發電系統進行了研究分析。第2章分析了未來清潔煤應用的煤基多聯產系統和目前大型燃煤電站使用的IGCC發電系統，設計了以發電為主要目的的煤基SOFC/IGCC聯合循環發電系統，對系統的發電過程進行了分析和進行了系統的主要設備選型。第3章就提高整體式煤氣化聯合循環（IGCC）系統的關鍵環節煤氣化與凈化系統進行了研究，運用ASPEN PLUS軟件建立了Texaco氣化爐模型，分析了水煤漿濃度、氧煤比、氧氣濃度對氣化爐的影響，最后運用低溫甲醇洗法對德士古(Texaco)氣化爐產生的粗煤氣進行了凈化。第4章針對煤基SOFC/IGCC聯合循環發電系統中的SOFC部分運用大型多物理場耦合軟件COMSOL進行了平板式單體SOFC的流動與傳熱模擬分析。第5章運用ASPEN PLUS軟件建立了煤基SOFC/IGCC聯合循環發電系統模型，設定參數計算后，得出SOFC/IGCC聯合循環發電系統的發電功率比單個IGCC系統發電功率高出近10個百分點的結論。然后就影響SOFC/IGCC聯合循環發電系統功率的參數SOFC堆運行壓力、SOFC工作溫度、燃料利用率和燃?xì)廨啓C負荷進行了分析，分析表明，提高SOFC堆的運行壓力可以有效提高SOFC/IGCC聯合循環發電系統的發電效率，SOFC的最適宜溫度是800℃-1000℃，系統的最佳燃料利用率在85%左右。

關鍵詞 SOFC；煤氣化；IGCC；聯合循環發電系統


Abstract
Coal-based SOFC/IGCC combined cycle power generation system is the advanced energy power system which has combined the advanced fuel cell technology with the overall style of gasification combined cycle. Now it has entered the operational phase of commercial demonstration. It is one of the world's most effective power generation systems in achieving near-zero coal-fired pollution, and has highly received the attention of countries all over the world.
This paper has studied and analyzed coal-based SOFC/IGCC combined cycle power generation system. The second chapter has analysed the coal polygeneration system of the future application of clean coal and the IGCC power generation system, designed the coal-based SOFC/IGCC combined cycle power generation system whose main purpose is to generate electricity, analyzed the generation process of the system, and did the systematic selection of the system's major equipment. The third chapter has studied on how to improve the gasification and purification for the key parts of integral combined cycle (IGCC) coal gasification power system, used ASPEN PLUS software to establish a Texaco gasifier model to analyze the coal slurry concentration, oxygen-coal ratio, the impact of oxygen concentration on the gasifier, and ultimately uses low-temperature methanol wash method to purify the crude gas produced by Texaco gasifier. The fourth chapter has focused on the SOFC part of the coal-based SOFC/IGCC Combined cycle power generation system to use the large-scale multi-physics coupling software COMSOL for the simulation analysis of flat SOFC unit's flow and heat transfer. The fifth chapter has used ASPEN PLUS software to establish a SOFC/IGCC combined cycle power system model. After setting the parameter and calculating, the result can be gotten that the generated output of SOFC/IGCC combined cycle power generation system is higher than a single IGCC power generation system by almost 10 percentage points. Then, it has analyzed the parameters of SOFC/IGCC combined cycle power generation system, such as the operating pressure of SOFC stack, the operating temperature of SOFC, fuel efficiency and gas turbine load factor. The analysis shows that improving the operating pressure of SOFC stack can improve the efficiency of SOFC/IGCC combined cycle power generation system; the most suitable temperature of SOFC is 800℃-1000℃, while the best fuel efficiency of the system is about 85%.
Keywords: SOFC; coal gasification; IGCC; combined cycle power generation system

目錄
摘要 I
ABSTRACT II
目錄 III
Contents V
第1章 緒論 1
1.1課題背景與實際意義 1
1.2國內外發展現狀及存在的問題 2
1.2.1 IGCC發展歷程 2
1.2.2 SOFC發展歷程 3
1.2.3 SOFC/IGCC聯合循環發電系統研究動態 5
1.2.4目前存在的問題 7
1.3本文的主要研究工作 7
第2章SOFC/IGCC聯合循環系統設計 8
2.1煤基多聯產系統概述 8
2.2整體式煤氣化聯合循環發電系統(IGCC) 10
2.2.1整體式煤氣化聯合循環發電系統(IGCC)的概念 10
2.2.2整體式煤氣化聯合循環發電系統(IGCC)的特點 12
2.3 SOFC/IGCC聯合循環發電系統設計 13
2.3.1 SOFC/IGCC聯合循環發電系統概述 13
2.3.2 SOFC/IGCC聯合循環發電系統的主要設備選型 14
2.4 小結 16
第3章 德士古水煤漿氣化工藝研究 17
3.1德士古煤氣化工藝 17
3.2基于ASPEN PLUS的德士古氣化爐模型及運行結果 19
3.2.1 基于ASPEN PLUS的德士古氣化爐模型 19
3.2.2氣化結果與分析 21
3.3煤氣凈化工藝 27
3.3.1煤氣凈化方法 27
3.3.2低溫甲醇洗法煤氣凈化工藝 28
3.4小結 29
第4章 板式固體氧化物燃料電池(SOFC)本體性能研究 31
4.1 SOFC模型的建立 31
4.1.1 SOFC模型假設 31
4.1.2 SOFC數學模型 32
4.2仿真結果與分析 33
4.3小結 37
第5章 SOFC/IGCC聯合循環系統性能分析 38-b..